Bedienungsanleitung Graupner ULTRA TRIO PLUS 16 - 6469 (Seite 41 von 107) (Deutsch, Englisch, Französisch, Italienisch)

637232

Zoom out

Zoom in

Vorherige Seite

1/107

Nächste Seite

The fundamental rule is that Lithium-based batteries may ONLY be charged using spe-

cial chargers, and the charge program must be set up correctly in terms of ﬁ nal charge

voltage and capacity for the battery type in use. The charge process is fundamentally

different to that required for Ni-Cd or Ni-MH batteries, and is termed a constant current

/ constant voltage method. The charge current required varies according to the battery

capacity, and is set automatically by the charger. Lithium batteries are usually charged

at the 1C rate (1C charge rate = half capacity as charge current. Example: battery

capacity 1500 mAh: 1C charge current = 1500 mA = 1.5 A).

Because some types can be charged with upt to 2C or 4C charging current, the charging current and the

capacity of the battery must be set seperately. When the battery on charge reaches the speciﬁ c ﬁ nal voltage

which is appropriate to the battery type, the charger automatically reduces the charge current in order to prevent

the battery exceeding the ﬁ nal permissible voltage. If the battery manufacturer states a charge current lower

than the 1C rate, then the capacity (charge current) must be reduced accordingly.

We recommend the use of the balancer connector, which ensures that your Lithium batteries are

charged optimally, and therefore increases safety and their useful life.

Problems caused by mistreating batteries:

It is very dangerous to overcharge Lithium-Ion batteries, as they tend to react by gassing, overheating and

even exploding. If the ﬁ nal charge voltage of 3.6 V / cell (LiFePO

), 4.1 V / cell (Lithium-Ion) or 4.2 V / cell

(Lithium-Polymer and Lithium-Manganese) is exceeded by more than 1%, the lithium ions in the cell start to

change into metallic lithium. This material reacts very violently with the water in the electrolyte, and this can

result in the cell exploding. On the other hand it is also important to avoid terminating the charge process before

the ﬁ nal charge voltage is reached, since this reduces the effective capacity of the Lithium-Ion cell markedly.

Stopping the charge at just 0.1 V under the threshold means a capacity loss of around 7%. Lithium batteries

must not be deep-discharged, as this leads to a rapid loss of capacity. This effect is irreversible; it is absolutely

vital to avoid discharging the batteries to below 2.5 V / cell.

Caution: the cell type, cell capacity and cell count set on the charger must always be correct for the

battery to be charged; if you make a mistake, the battery could explode and burn! Never connect a

Lithium-based battery to the charger if it features an integral charge circuit! Always place your Lithium

batteries on a non-ﬂ ammable surface for charging.

charge time

current

voltage

13. Lithium programs (Output 1)

These programs are only suitable for charging and discharging LiFePO

batteries with a voltage of 3.3 V

/ Cell, Lithium-Ion batteries with a voltage of 3.6 V / cell, and Lithium-Polymer and Lithium-Manganese

batteries with a voltage of 3.7 V / cell. The outstanding feature of Lithium batteries is their much higher

capacity compared to other battery types. However, this important advantage is offset by the need

to adopt different handling strategies: they must be charged and discharged using speciﬁ c methods,

otherwise they will be damaged, and can be dangerous. The directions in these instructions must be

observed at all times when handling these batteries. Speciﬁ c information and safety notes will also be

found in the battery manufacturer’s technical information.

Lithium

MANUAL-

program

Lithium

discharge

program

Lithium

type

select

MODE MODE

MODE

Lithium

storage

program

MODE

Missbrauch melden von Frage und/oder Antwort

Libble nimmt den Missbrauch seiner Dienste sehr ernst. Wir setzen uns dafür ein, derartige Missbrauchsfälle gemäß den Gesetzen Ihres Heimatlandes zu behandeln. Wenn Sie eine Meldung übermitteln, überprüfen wir Ihre Informationen und ergreifen entsprechende Maßnahmen. Wir melden uns nur dann wieder bei Ihnen, wenn wir weitere Einzelheiten wissen müssen oder weitere Informationen für Sie haben.

Graupner ULTRA TRIO PLUS 16 - 6469 Seite 41

Brauchen Sie Hilfe? Stellen Sie Ihre Frage.

Missbrauch melden von Frage und/oder Antwort

Art des Missbrauchs:

Forenregeln

Neu registrieren

Das Handbuch wird per E-Mail gesendet. Überprüfen Sie ihre E-Mail.

Ihre Frage wurde zu diesem Forum hinzugefügt

Info