484678
7
Zoom out
Zoom in
Vorherige Seite
1/14
Nächste Seite
5
Installation instructions
& Please fold out the page with diagrams!
Read the installation instructions prior to starting work and
follow them carefully!
Intended use
The Caravan Mover is designed for use with single-axle
caravans with a total weight of up to 1700 kg.
Installation using the standard installation kit is only possible
on caravans/trailers within the following dimensions.
min.
195*
max. 1760
max. 2400
min. 140
min. 30
max. 48
min. 185
min. 2.8
max. 3.5
min. 330
Caravan Floor
all dimensions in mm
* with fully loaded vehicle
A distinction is made between L-profiled and U-profiled
chassis as shown in the illustration.
Caravan Floor
L-Profile
U-Profile
Measuring the chassis height
The chassis height (Y) is measured at point (X)
X
Y
Determining the installation type
1. Standard installation
Standard installation is used with an L-profile chassis and a
frame height (Y) of approx. 185 mm. No special accessories
are required.
2. Installation on a chassis with U-profile
Standard installation is used with a U-profile chassis and a
frame height (Y) of approx. 185 mm. A U-profile chassis kit
is needed to compensate for the profile edge.
3. Installation on a chassis with L-profile and frame
height of between 140 and 185 mm
With a chassis with a frame height (Y) of 140 mm to 185 mm,
1, 2 or 3 spacer plate sets and the U-bolt extension kit are
needed to compensate for the height.
4. Installation on a chassis with U-profile and frame
height of between 140 and 185 mm
The U-profile chassis kit, 1, 2 or 3 spacer plate sets and
the U-bolt extension kit are required to compensate for the
U-profile chassis edge and the height.
5. Installation on a chassis with L- and U-profiles with
frame height of less than 140 mm
On a chassis with a frame height (Y) of less than 140 mm a
low chassis kit must be fitted to compensate the height.
In Germany, the low chassis kit installation must be
accepted by a vehicle expert.
6. The AL-KO Vario III / AV installation kit must be used
with the AL-KO Vario III / AV chassis with a frame thickness of
less than 2.8 mm.
Special accessory installation
1. U-bolt extension kit
(for chassis with L-profile, frame height
from 140 to 185 mm)
U-bolts, nuts and washers,
Part no. 60010-00100.
1.1. Spacer plate kit
(two 15 mm spacer plates)
for height compensation
max. 45 mm (3 plates) at
each side (e.g. installed
behind axle)
Part no. 60010-66000.
2. Low chassis kit
for height compensation for
caravan/trailer with frame height of
less than 140 mm,
Part no. 60010-64900.
In Germany, this installation
kit must be accepted by
a vehicle expert.
3. U-profile chassis kit
(for chassis with U-profile,
frame height approx. 185 mm)
U-bolt with clamping plates and
self-locking nuts, stoppers
Part no. 60010-09200.
4. AL-KO Vario III / AV
Installation kit
for caravans with
AL-KO Vario III / AV Chassis
2.8 mm) mandatory,
Part no. 60010-21500.
5. Cross actuation device
(for swivelling both drive units
against the wheels from one
side and releasing them again)
connecting tube, middle tube,
nuts, bolts, grub screws,
Part no. 60010-18500.
The Caravan Mover is not approved for installation
on caravans/trailers with any other chassis! Any
drilling (exception: when using flat frame kit) or welding to the
chassis is not allowed. Under no circumstances remove any
suspension components from the chassis.
7

Brauchen Sie Hilfe? Stellen Sie Ihre Frage.

Forenregeln

Missbrauch melden von Frage und/oder Antwort

Libble nimmt den Missbrauch seiner Dienste sehr ernst. Wir setzen uns dafür ein, derartige Missbrauchsfälle gemäß den Gesetzen Ihres Heimatlandes zu behandeln. Wenn Sie eine Meldung übermitteln, überprüfen wir Ihre Informationen und ergreifen entsprechende Maßnahmen. Wir melden uns nur dann wieder bei Ihnen, wenn wir weitere Einzelheiten wissen müssen oder weitere Informationen für Sie haben.

Art des Missbrauchs:

Zum Beispiel antisemitische Inhalte, rassistische Inhalte oder Material, das zu einer Gewalttat führen könnte.

Beispielsweise eine Kreditkartennummer, persönliche Identifikationsnummer oder unveröffentlichte Privatadresse. Beachten Sie, dass E-Mail-Adressen und der vollständige Name nicht als private Informationen angesehen werden.

Forenregeln

Um zu sinnvolle Fragen zu kommen halten Sie sich bitte an folgende Spielregeln:

Neu registrieren

Registrieren auf E - Mails für Truma Mover Caravan Mover 2 wenn:


Sie erhalten eine E-Mail, um sich für eine oder beide Optionen anzumelden.


Das Handbuch wird per E-Mail gesendet. Überprüfen Sie ihre E-Mail.

Wenn Sie innerhalb von 15 Minuten keine E-Mail mit dem Handbuch erhalten haben, kann es sein, dass Sie eine falsche E-Mail-Adresse eingegeben haben oder dass Ihr ISP eine maximale Größe eingestellt hat, um E-Mails zu erhalten, die kleiner als die Größe des Handbuchs sind.

Ihre Frage wurde zu diesem Forum hinzugefügt

Möchten Sie eine E-Mail erhalten, wenn neue Antworten und Fragen veröffentlicht werden? Geben Sie bitte Ihre Email-Adresse ein.



Info