Bedienungsanleitung Benekov R100 (Seite 22 von 32) (Englisch)

693645

Zoom out

Zoom in

Vorherige Seite

1/32

Nächste Seite

 it is forbidden to overheat the boiler

 the boiler must be protected from corrosion caused by low temperature of returning water by

means of a suitable connection with automatic temperature control of returning water

 only listed fuel can be combusted in the boiler

 it is forbidden to store combustible materials near the boiler

 it is necessary to minimize the risk of ignition of the fuel container by suitable setting of

attenuation parameters

 when operating the boiler, it is necessary to pay maximum attention to heat sources as they may

cause burns

c) Risks connected to manipulation with fuel

 during manipulation with fuel, solid particles are emitted. Therefore, the operator should,

depending on the degree of dustiness, use suitable protective equipment.

 because of the risks connected to manipulation with fuel, it is necessary to comply with

applicable fire regulations and a fire extinguisher must be available

d) Ergonomic risks

 the boiler must be in a horizontal position

 it is forbidden to insert hands in the worm conveyor

 during operation of the boiler, all doors, covers and guards must be closed properly

8. Boiler maintenance

1.)

It is important to refill the fuel in time. As soon as there is only a small amount of fuel in the

container, it must be refilled immediately to prevent false air or smoke from entering the container.

ATTENTION: The lid of the fuel bin must be closed properly.

2.) If the boiler is well-adjusted, the ash appears in the form of a fine powder which falls in the ashtray.

As the combustion area has a self cleaning function, the ashtray needs to be emptied only once a

week during regular operation. Use protective gloves for this activity.

3.) If the boiler runs continuously, it is recommended to clean the heat transfer surface of the body of

the boiler once a month. The heat exchange surfaces become contaminated in course of the

operation, which may significantly impair the heat transfer and the efficiency of the boiler.

It is also important to clean occasionally (once a month) the inner part of the grate as any possible

sediments influence negatively the flow of air in the burner nozzles.

It is recommended to shut down the boiler (switch off the main switch) at least 1 hour before

cleaning of the inner part of the grate is carried out. After the heating season the boiler must be

completely cleaned.

4.) Minerals contained in the wooden pellets can form crusts on the grate, which may lead to a

complete blockage of the worm-gear-system. To avoid this it is recommended that the burner area

be checked at least once a month and any hard sediment on the grate be removed manually.

5.)

Further, it is recommended that the outside of the gear engine and the ventilator be cleaned with a

dry brush from time to time. During the cleaning, the boiler must be disconnected from the

electrical power.

6.) A heat-resistant ceramic reflector and ceramic plates are installed over the burner. There is no

special care demanded. Ash may appear on the surface of the reflector, which can be removed, but

it does not impair the function of the device.

7.)

The engine is protected against damage with a thermo contact that ensures the protection against

burn off especially if the feed device becomes blocked (regular temperature of the engine can

reach 85°C). In case of overheating (if the critical temperature was exceeded) the thermo contact

shuts down the engine and the ventilator. In such a case, it is necessary to switch off the boiler, clear

the fuel from the container via the discharging gap and eliminate the fault. WARNING: before

Missbrauch melden von Frage und/oder Antwort

Libble nimmt den Missbrauch seiner Dienste sehr ernst. Wir setzen uns dafür ein, derartige Missbrauchsfälle gemäß den Gesetzen Ihres Heimatlandes zu behandeln. Wenn Sie eine Meldung übermitteln, überprüfen wir Ihre Informationen und ergreifen entsprechende Maßnahmen. Wir melden uns nur dann wieder bei Ihnen, wenn wir weitere Einzelheiten wissen müssen oder weitere Informationen für Sie haben.

Benekov R100 Seite 22

Brauchen Sie Hilfe? Stellen Sie Ihre Frage.

Missbrauch melden von Frage und/oder Antwort

Art des Missbrauchs:

Forenregeln

Neu registrieren

Das Handbuch wird per E-Mail gesendet. Überprüfen Sie ihre E-Mail.

Ihre Frage wurde zu diesem Forum hinzugefügt

Info