Bedienungsanleitung Nilfisk IV150 (Seite 39 von 60) (Deutsch, Englisch, Holländisch, Französisch)

19480

Zoom out

Zoom in

Vorherige Seite

1/60

Nächste Seite

INSTRUCTIONS FOR USE

32401106(1)2004-04 A 9

VACUUM CLEANER FOR

ASBESTOS

On vacuum cleaners with an accessory for the removal of

asbestos dust, the ABS container insert or the protective

bag system must always be used. An exhaust connection

must be attached to the side outlet, through which air can

be exhausted from the working area. The exhaust hose

can be directed to the open air or to a ventilation system

installed in the working area.

The exhaust connection for the air outlet must be fitted

with a 70 mm PUR H hose with a length of < 5 m. This

hose is contained in the Asbestos Kit, which can be

supplied for the machine. As already mentioned, the hose

can either be exhausted directly to the open air or to a

ventilation system installed in the working area.

When transporting the machine you must make sure that

it has been cleaned in accordance with the regulations

stipulated in TRGS 519. The machine can also be

transported in a sealed container from which no

contaminated dust can escape.

Filter replacement

Make sure that the filter is covered with a suitable plastic

bag before it is removed.

Remove the suction pipe “1” from the lower connection.

If the filter assembly is very heavy, remove the upper

cover and lift the assembly from the machine using the two

handles provided. Unscrew the clamp, which attaches the

filter to the basket, and lift the basket from the filter.

Rotate the filter and reveal the plastic strip “2”.

Place the filter in a plastic bag, cut the plastic strip and free

the basket from the filter.

Seal the plastic bag containing the filter.

If the filter is soiled by poisonous or otherwise dangerous

dust do not throw it away. Hand it to an authority, which is

authorised for the disposal of this type of waste.

Take particular care when replacing the main filter or the

complete filter and wear a P3-type mask.

Obtain a filter with the same characteristics as the old filter

and proceed as follows: (Fig. 17).

Fit the filter lock and the sealing ring of the old filter to the

new filter.

Insert the cage “4” and secure the filter using the plastic

strips “2” on the bottom of the filter.

Fit the filter rods in the filter shaking system and tighten the

screw.

Fit the upper cover on the filter unit.

Re-insert the filter unit into the machine.

Re-attach the suction pipe “1” in its original position.

Fix the clamp, which holds the filter unit on the machine.

ABSOLUTE FILTER

HEPA filter “1” must be installed when the vacuum must

operate in clean-room environments, when a high degree

of purity is required or when it must treat materials that are

dangerous for the operator.

This filter is installed in the filter compartment on the top of

machine, between the primary filter and the blower unit.

This allows the machines to achieve 99.995% MPP

efficiency at a particle size of 0.3 Micron, in retaining the

particles that escape the primary filter.

This value was gauged by means of the D.O.P. method.

NOTE

If the machine is to be used for the suction

removal of asbestos dust, either the ABS

container or the protective bag system must

be used.

ATTENTION!

The replacement of the filter is an important

procedure.

The filter must be replaced by another filter

with the same characteristics and the same

filter surface and category. If these rules are

not followed the vacuum cleaner may not

function correctly.

Missbrauch melden von Frage und/oder Antwort

Libble nimmt den Missbrauch seiner Dienste sehr ernst. Wir setzen uns dafür ein, derartige Missbrauchsfälle gemäß den Gesetzen Ihres Heimatlandes zu behandeln. Wenn Sie eine Meldung übermitteln, überprüfen wir Ihre Informationen und ergreifen entsprechende Maßnahmen. Wir melden uns nur dann wieder bei Ihnen, wenn wir weitere Einzelheiten wissen müssen oder weitere Informationen für Sie haben.

Nilfisk IV150 Seite 39

Brauchen Sie Hilfe? Stellen Sie Ihre Frage.

Missbrauch melden von Frage und/oder Antwort

Art des Missbrauchs:

Forenregeln

Neu registrieren

Andere Handbücher von Nilfisk IV150

Das Handbuch wird per E-Mail gesendet. Überprüfen Sie ihre E-Mail.

Ihre Frage wurde zu diesem Forum hinzugefügt

Info