Bedienungsanleitung SMC Super 100 (Seite 20 von 26) (Englisch)

550805

Zoom out

Zoom in

Vorherige Seite

1/26

Nächste Seite

Battery Service

If the motorcycle is operated with an insufficient (low)

battery electrolyte level, sulfation and battery plate damage

may occur. Inspecting and maintaining the electrolyte

level is a simple, quick operation, therefore, it should be

performed frequently as indicated in the Service Schedule

(page 14-15)

1 The 12V-4AH battery 1. is mounted within the

frame center. Remove the battery cover and check

the battery electrolyte. The correct electrolyte level is

between the lower and upper level marks 3., 4. on the

battery case.

2 To correct the electrolyte level, remove the battery cell

caps from the cells needing level correction. For case

of cell level correction a small syringe or plastic funnel

should be used. Carefully add the proper amount of

distilled water to bring the electrolyte level of the cells

between the lower and upper marks.

1 Battery

2 Lower level marks

3 Upper level marks

For maximum battery performance and life, only distilled

water should be added, however, in an emergency situation

where electrolyte water or low and distilled water is not

available, drinking water or a low mineral content water can

be used. Reinstall the cell caps.

NOTE:

BATTERY REMOVAL MAY BE NECESSARY WHEN BATTERY

ELECTROLYTE (SPECIFICGRAVITY) READING IS BELOW

1,200, INDICATING THE NEED OF BATTERY RECHARGING,

OR WHEN THE BATTERY IS REMOVED FOR STORAGE.

3 Disconnect the ground (-) negative

cable connection and the positive(+) cable

last. Note the positioning of the cables, and the

battery mount rubber pads as well as the routing of the

battery vent tube. Before installing the battery,

clean the battery. Baking soda and water can be used

to remove any existing corrosion.

4 When considerable amount of night riding is

planned or if turn signal is used extensively, there

will be considerable drain on the battery. To adjust

the system to this condition, change the green

generator load from the red (normal change) connector

to the transparent covered connector (high charge).

This will provide a higher battery charging rate and

prevent possibility of battery becoming discharged.

NOTE:

1 ADD ONLY DISTILLED WATER TO THE BATTERY, NEVER

USE TAP WATER.

2 WHEN REPLACING THE BATTERY

INTO THE COMPARTMENT, MAKE SURE THAT THE

VENT TUBE OF THE BATTERY IS PROPERLY ATTACHED

TO AND NOT PINCHED OR BLOCKED.

3 IF UNUSUAL HIGH RATE OF BATTERY

ELECTROLYTE LOSS IS EXPERIENCED, CONSULT

YOUR SUPER DEALER FOR A CHECK.

Wheel removal

Removal of front and rear wheel is performed in the

following manner.

1 Front wheel

a. Raise the front wheel of the ground by putting the

motorcycle on the centre stand.

b. Remove speedometer cable and front brake

cable from the front brake panel assembly.

c. Remove the front axle nut.

d. Pull out the front axle and the front wheel can be

removed from the frame.

2 Rear wheel

a. Remove the chain guard..

b. Loosen the rear axle nut, sleeve nut, drive chain

adjusting nut and disconnect the drive chain at

the joint clip.

c. Remove the rear brake adjusting nut and remove

the rear brake rod from the brake arm.

d. Remove the rear torque arm bolt at the rear brake

panel.

e. Pull out the rear axle and the rear wheel can be

removed from the frame.

NOTE:

DURING REASSEMBLY, THE DRIVE CHAIN JOINT SHOULD

BE INSTALLED IN THE WAY THAT THE OPEN END WILL

FACE OPPOSITE TO THE DIRECTION OF ROTATION.

Missbrauch melden von Frage und/oder Antwort

Libble nimmt den Missbrauch seiner Dienste sehr ernst. Wir setzen uns dafür ein, derartige Missbrauchsfälle gemäß den Gesetzen Ihres Heimatlandes zu behandeln. Wenn Sie eine Meldung übermitteln, überprüfen wir Ihre Informationen und ergreifen entsprechende Maßnahmen. Wir melden uns nur dann wieder bei Ihnen, wenn wir weitere Einzelheiten wissen müssen oder weitere Informationen für Sie haben.

SMC Super 100 Seite 20

Brauchen Sie Hilfe? Stellen Sie Ihre Frage.

Missbrauch melden von Frage und/oder Antwort

Art des Missbrauchs:

Forenregeln

Neu registrieren

Das Handbuch wird per E-Mail gesendet. Überprüfen Sie ihre E-Mail.

Ihre Frage wurde zu diesem Forum hinzugefügt

Info